You can make an all-duck sausage. Any of you who make sausage know this is no small order. Duck fat is far lower in saturated fat than pork fat, and that low melting point makes its use in charcuterie tricky, to say the least.
But it can be done, if you emulsify the sausage. Emulsify? As in salad dressing or hollandaise? Exactly. Only emulsifying meat is a little harder than a hollandaise. Everything involved in the process must be super clean and super cold, colder even than with regular sausage. Oh, and you need a big food processor. And some dry milk doesn’t hurt, either. More on that later.
I’ve done this before, most successfully with my duck mortadella. Mortadella, incidentally, is what bologna dreams of becoming when it grows up. That sausage is dreamy, light, almost… fluffy. Holly and I ate several pounds within a matter of days.
I wanted this duck dog to be a “red” sausage, and to me that means paprika. Lots of paprika. I also planned to smoke these links cold, something I can do on a cool day with my smoker.
So as I got to work, I soon realized I needed to go a little further with my spices. So, more or less randomly, I chose to add some smoked paprika, marjoram, black pepper and garlic powder. Seemed like a good combination at the time.
In general, the process of making an emulsified sausage goes like this:
- Get everything together: casings, spices, salts, etc. Put equipment in the fridge or freezer.
- Chop meat and fat then partially freeze it so it can stiffen up. Grind it fine and put back in the freezer.
- Mix the meat with some ice cold liquid in a food processor. Hope like hell the emulsion holds.
- Stuff into casings, poach gently to set. Smoke for a few hours if you want.
If all goes well, and this time it did, you get a sausage with a very smooth texture that is light yet rich. Ideally, it isn’t too smoky or too heavily spiced. And when you take a bite, it tastes like what you want it to — only in this case I wasn’t totally certain what it would taste like.
So I had to laugh when I took that first bite. It was indeed a hot dog. No getting around it. I rushed over to my charcuterie books and looked up their hot dog recipes. And of course I saw garlic powder, paprika, marjoram, pepper and, usually, nutmeg or coriander. Damn. Reinvented the wheel again.
You do need some special equipment to make this recipe. Gather together:
- A sausage grinder; I use a Weston grinder, but there are many good ones on the market.
- A stuffer (do NOT use the Kitchenaid stuffer, it’s terrible); I use a vertical sausage stuffer from The Sausage Maker.
- Casings. Traditionally hot dogs are made with sheep casings, but I used regular hog casings, which you can buy in most butcher shops or online.
- You will also need Instacure No. 1, which is sodium nitrite. You need this for color, flavor — and to protect yourself from bacteria. You are smoking the sausages at a very low temperature, a temperature bacteria just love. If you skip the Instacure, you increase your risk of food poisoning, and you will not be making a hot dog. It will look and taste very different, so be forewarned.
- A smoker. I smoked these links over oak, but any hardwood would be fine. I use a Traeger, but there are many good ones out there.
- Duck fat. You need 1/4 pound of duck fat to make this recipe. I rendered my own wild duck fat, but you can buy it in specialty supermarkets or online.
- Dry milk. This really helps your emulsion. The dry milk absorbs water and will make an emulsion more stable.
Phew! Ready now? OK, get all your meat, fat and equipment clean and cold before you start.
Duck Hot Dogs
- 1 1/2 pounds duck or goose meat
- 1/2 pound duck or goose skin
- 1/4 pound rendered duck or goose fat (start with it frozen)
- 18 grams kosher salt, about a tablespoon
- 35 grams dry milk, about 1/2 cup
- 1/2 teaspoon Instacure No. 1
- 1/2 teaspoon black pepper
- 1 teaspoon garlic powder
- 1/2 teaspoon smoked paprika
- 1 teaspoon dried marjoram
- 1 tablespoon sweet paprika
- A scant 1/2 cup ice water
- Soak your casings in a bowl of warm water. When they are soft, run water through them to check for leaks.
- Chop the meat into pieces small enough to grind. Set the meat in the fridge. Chop the skin into small pieces, about 1/2 inch each. Set it in the freezer. When the skins are stiff but not rock hard, about 1 hour, grind them through the fine die of your grinder. Do the same for the meat. Check the temperature: If the meat and skin is anywhere below 35°F, you can proceed. If not, put it in the freezer until it gets cold enough.
- You will now need to work fast, so have everything ready. When the meat and skin is between 28 to 32°F, put it into a food processor along with 1/2 of the ice water. Buzz it to emulsify, about 30 seconds to 1 minute. Add everything else to the food processor and emulsify that, which will take a minute or two. (If your food processor is not big enough to handle this job, you will need to split everything into two batches evenly. Keep the second batch of meat, skins and fat in the freezer while you work with the first batch.)
- Put the mixture into the sausage stuffer, which you've been keeping in the fridge. Put the stuffer, now filled with your sausage, back into the fridge as you clean up. Take the stuffer out and stuff your casings.
- Tie off links at whatever interval you want; I used hog casings here, and I made the links about 5-6 inches each. It is important to tie off your links with kitchen string, even if you normally twist off your links. The string prevents the links from unraveling when you poach them.
- When all the links are tied, hang in a cool place while you get a big pot of water hot. As the water is heating, prick any air bubbles in the links with a pin or needle that you've sterilized in the stovetop's flame. When the water reaches 170 to 175°F -- this is below a simmer -- gently put the sausages in and poach for 25 minutes. Be careful to not let the water temperature get past 178°F, or the links can burst.
- As the links are poaching, get an ice water bath ready. When 25 minutes are up, shock the sausages in ice water for 5 minutes.
- Smoke over oak, applewood, etc. for 3-5 hours. It is important that your smoker be as cool as possible. I turn my Bradley smoker on, but leave the heater off. Once the links are smoked, let them cool on a rack for a couple hours, and then overnight in the fridge before you seal and freeze them. They will last 7-10 days in the fridge or indefinitely once sealed and frozen.